Order Information
Client
LIBERTY MUTUAL/SAFECO COMMERCIAL LINES
Claim ID
AB220-306078
Order Date
6/2/2021 10:45:42 AM
Inspector
FP103
Contract Number
NA
Insured Party
PRIVATE
Vehicle Year
2021
Vehicle Make
FORD
Vehicle Model
F150
Vehicle VIN Number
1FTFW1E53MFA42197
Vehicle Mileage
VFY
Inspection Location
Name
FLOOD FORD SUPER COLLISION CENTER
Address
2545 S COUNTY TRAIL
City
EAST GREENWICH
State, Zip
RI, 02818
Phone
4018844000
Contact(s)
SERVICE
Adjuster Name
TAYLOR DONOVAN
Extension
617-654-4311
Email
TAYLOR.DONOVAN@LIBERTYMUTUAL.COM
Reason For Inspection
THE VEHICLE IS OWNED BY ENTERPRISE RENTAL INSURED WAS DRIVING DOWN A HILL. HE WAS GETTING OFF THE INTERSTATE AND THE BRAKES MALFUNCTIONED. HE TRIED TO APPLY AS MUCH PRESSURE TO THE BRAKES, BUT THE VEHICLE DID NOT STOP. INSURED MADE THE DECISION TO TURN LEFT AND GAIN AS MUCH RADIUS AS POSSIBLE TO AVOID MAJOR IMPACT. IMPACT TO THE REAR RIGHT SECTION OF THE VEHICLE. CHECK THE VEHICLE FOR SIGNS OF A BRAKE MALFUNCTION, CHECK FOR BRAKE PEDAL FADE, LEAKS, CONTAMINATION TO THE BRAKE FLUID, ANY BRAKE OR ABS WARNING LIGHTS ON, ROAD TEST IF POSSIBLE TO CHECK FOR BRAKE ISSUES
Report Information
Location Contact
AUSTIN
Contact Title
AUSTIN
Inspection Date
6/3/2021 8:17:00 AM
Vehicle Year
2021
Vehicle Make
FORD
Vehicle Model
F150<
Current VIN Number
1FTW1E53MFA42197
Vehicle VIN Number Originally Submitted as
1FTFW1E53MFA42197
Vehicle Production Date
12/20
Current Mileage
5,063
Vehicle Mileage Originally Submitted as
VFY
Vehicle Trim
LARIAT
Labor Rate / Type
135.0000
PROVIDED VERBALLY
Engine Type
V-8 5.0 LITER
Engine Emissions
CALIFORNIA
Transmission / Model
AUTOMATIC
Wheel Drive Type
FOUR WHEEL DRIVE (4X4)
Vehicle Plate #
93644
Engine Oil Level
Low
Engine Oil Condition
Good
Coolant Level
Full
Coolant Condition
Good
Transmission Level
N/A
Transmission Condition
N/A
Power Steering Level
N/A
Power Steering Condition
N/A
Brake fluid Level
Full
Brake Fluid Condition
Good
Front Differential Fluid Level
N/A
Front Differential Fluid Condition
N/A
Rear Differential Fluid Level
N/A
Rear Differential Fluid Condition
N/A
Transfer Case Level
N/A
Transfer Case Condition
N/A
Oil Filter Brand
OEM
Sample Taken
N
Sample Type
Miscellaneous Comments
Commercial Use
YES, RENTAL VEHICLE
Signage
NO
Modifications
NO
Collision
NO
Tow Hitch
YES,
Towed or Driven In
DRIVEN
Belts
GOOD
Hoses
GOOD
All Tires Match
YES
Tire Size
275/65/18
Factory Tire Size
275/65/18
Overall Condition
GOOD
Customer Complaint, Date Opened, Shop Name on Repair Order
CUSTOMER STATES BRAKES ISSUES LOSS F BRAKING HAD CODES
C059A C0609 U 3000 U3003 .AT TIMES VEHICLE LOOSES ALL BRAKING POWER AT ALL
06/03/2021
FLOOD FORD OF EAST GREENWICH
Facility Repair Order
694951
State of Assembly (be specific)
ASSEMBLED AND DRIVABLE
Related Recalls, TSB's, or Service History
Failed Components and Extent of Damage
1. AT THE TIME OF THIS INSPECTION THERE IS NO EVIDENCE OF BRAKE FLUID LEAKS.
2. AT THE TIME OF THIS INSPECTION THERE IS NO EVIDENCE OF CONTAMINATION TO THE BRAKE FLUID.
3. THE ABS LIGHT IS ON.
4. THE E BRAKE LIGHT IS ON
5.THE SERVICE TRAC SYSTEM MESSAGE IS DISPLAYED
6.THE TECHNICIAN DROVE THE VEHICLE WITH THE INSPECTOR FOR 1.5 MILES AT SPEEDS OF 0 TO 35 MPH.
7.AT THE TIME OF THIS INSPECTION THERE WAS NO EVIDENCE OF BRAKE FADE.
8. EACH TIME THE BRAKES WERE APPLIED THE BRAKE WOULD APPLY ITSELF THIS OCCURRED APPROXIMATELY 10 TIMES.
9. THE TECHNICIAN PERFORMED A REAL TIME SCAN THE RESULTS ARE AS FOLLOWS:
C0954 BRAKE BOOSTER MOTOR PERFORMANCE
C05CC BRAKE MASTER CYLINDER PISTON POSITION SENSOR CIRCUIT RANGE PERFORMANCE
U0415 INVALID DATA RECEIVED FROM ANTI LOCK BRAKE SYSTEM ABS
U3003 BATTERY VOLTAGE
U3000 CONTROL MODULE
P1935 BRAKE SWITCH SENSOR SIGNAL
Measurements
ALL BRAKE PADS MEASURE GREATER THAN 8MM
Cause of failure
FURTHER DIAGNOSIS IS REQUIRED TO DETERMINE EXACT CAUSE OF BRAKING CONCERNS.
Recommendations for Repair
FURTHER DIAGNOSIS IS REQUIRED
Images
LEFT REAR BRAKE PAD MEASUREMENT
RT REAR BRAKE PAD MEASUREMENT
LEFT FRONT BRAKE PAD MEASUREMENT
RT FRONT BRAKE PAD MEASUREMENT
RT FRONT CALIPER AND BRAKE PADS
LEFT FRONT CALIPER AND BRAKE PADS
LEFT REAR CALIPER AND BRAKE PADSLEFT FRONT CALIPER AND BRAKE PADS
RT REAR CALIPER AND BRAKE PADS
RT REAR CALIPER AND BRAKE LINE
LEFT REAR BRAKE LINE AND CALIPER
REAR BRAKE LINES
RT FRONT BRAKE LINE HOSE
LEFT FRONT BRAKE LINE HOSE
LEFT REAR TIRE SIZE
LEFT FRONT TIRE SIZE
UNDER CARRIAGE LOOKING FORWARD
REAR BRAKE LINES
UNDER CARRIAGE LOOKING FORWARD
UNDER CARRIAGE LOOKING FORWARD
OIL FILTER
UNDER CARRIAGE LOOKING REARWARD
REPAIR ORDER
REPAIR ORDER
BACK OF REPAIR ORDER
ENGINE OIL DIPSTICK
ENGINE OIL DIPSTICK
COOLANT RESIVIOR
ENGINE PLACARD
ENGINE BAY
BRAKE LINES AND MASTER CYLINDER AND MODULATOR
BRAKE LINES AND MASTER CYLINDER
BRAKE MASTER CYLINDER RESIVIOR
BRAKE FLUID RESIVIOR CAP
BRAKE FLUID
BRAKE LINES
BRAKE LINES AT MASTER CYLINDER
DASH VIN TAG
NO STATE INSPECTION STICKER
FRONT OF VEHICLE WITH LICENSEPLATE
LEFT SIDE OF VEHICLE
RT SIDE OF VEHICLE
REAR OF VEHICLE WITH LICENSE PLATE
RT SIDE OF VEHICLE
LEFT SIDE OF VEHICLE
TIRE PLACARD
DOOR VIN TAG
ODOMETER BEFORE TEST DRIVE
ODOMETER BEFORE TEST DRIVE
NO LOF STICKER
GENERAL INTERIOR
GENERAL INTERIOR
BRAKE MASTER CYLINDER AND BRAKE LINES
REAL TIME SCAN
REAL TIME SCAN
REAL TIME SCAN
REAL TIME SCAN
REAL TIME SCAN
REAL TIME SCAN
SERVICE ADVANCE TRAC LIGHT ON
ABS AND E BRAKE ON
ODOMETER AFTER TEST DRIVE
ODOMETER AFTER TEST DRIVE
BRAKE PEDAL
BRAKE PEDAL MOUNT
APPLYING BRAKES